Whole Foods closing regional kitchens – Listeria findings

Posted on January 25, 2017 by

0


Whole Foods Market Inc is closing its North Atlantic food-preparation facility at 9 Commercial St., Everett, MA on March 17, 2017. The kitchen facility ceased food production on Monday.

Whole Foods is also closing regional kitchen facilities in Atlanta, Georgia and Landover, Maryland.

Whole Foods received a U.S. FDA warning letter on June 8, 2016 that listed the following findings:

  • On February 10, 2016, you were mixing ready to eat pesto pasta directly under an area in the Assembly Room where condensate from ceiling joints was dripping onto the surface below.
  • On February 16, 2016, you were storing an uncovered rack of ready to eat mushroom quesadilla in the same area of the Assembly Room where condensate from ceiling joints was dripping onto the surface below.
  • On February 10, 2016, your employee transported uncovered ready to eat vegetables through a doorway, from the Veg Prep Room into the Prepared Veg Cooler. A significant amount of condensate had formed above the doorway and was dripping onto the surface below.
  • On February 10, 2016, your employee was cutting chives and beets on a work surface directly underneath a leaking condensate drainage pipe in the Veg Prep Room.
  • On February 16, 2016, you were holding uncovered ready to eat egg salad in large white barrels that were placed in an area below the condenser. Condensate was observed to be dripping at a rate of approximately once per second from the condenser fan bolts in the K8/K9 Room.
  • On February 16, 2016, your employee transported uncovered ready to eat couscous through an area in the K8/K9 Room where condensate was dripping from an area around the condenser fan bolts at a rate of approximately once per second.
  • On February 10, 16, & 18, 2016, you were holding ready to eat vegetables, utensils such as cutting boards, mandolins, stainless colanders and yellow plastic totes in close proximity to hand a washing station in the Veg Prep Room. The hand washing station does not have splash guards and is foot operated releasing water from the faucets with significant pressure causing water to splash outside the sink while employees were observed washing soiled hands. Water splashed onto covered and uncovered ready to eat vegetables, utensils and food containers.
  • On February 16, 2016, your employee measured the strength of peracetic acid from the faucet in the Veg Prep Room with an (b)(4) Peracetic Acid test strip that indicated its strength over 160 ppm (maximum level on the test strip). This concentration exceeds the maximum level recommended by the (b)(4) product information sheet and the maximum level allowed under 21 CFR Part 173.315(a) (5) for use of peracetic acid for surface treatment and soaking and rinsing of vegetables.
  • On February 16, 2016, your employee was performing multiple tasks in the Pre-Pack Room including filling and weighing ready to eat egg salad in retail packs. The employee was observed cleaning and directly contacting work surfaces and then packaging and handling exposed product without hand washing or changing gloves in between tasks.
  • On February 16, 2016, your employee in the Bulk-Pack Room was observed assembling bulk cartons while also packaging exposed ready to eat quinoa cakes without hand washing or changing gloves in between tasks.
  • On February 16, 2016, your employee in the Pre-Pack Room was spraying (b)(4) quaternary ammonium based sanitizer to clean work surfaces while another employee in close proximity was packaging exposed ready to eat mesculin salad. This resulted in the sanitizer being sprayed onto an open colander of salad leafy greens.
  • On February 16, 2016, your employee’s unprotected upper sleeves were frequently touching ready to eat leafy salad greens as leafy salad greens were packaged into retail packs in the Pre-Pack Room.

In the following paragraph, the inspections detected Listeria on food contact surfaces.

FDA laboratory analysis of these subs confirmed the presence of non-pathogenic bacteria Listeria welshimeri in swab #39. Swab #39 was collected from the internal rotating drum portion, a food contact surface, of the (b)(4) vegetable chopping machine located in the Veg Prep Room. The presence of Listeria spp., such as the non-pathogenic Listeria welshimeri, detected on a food contact surface in your manufacturing facility is specifically used as an indicator for the probable presence of Listeria monocytogenes in your processing environment. This finding demonstrates that conditions exist in and on your equipment that would support the presence and growth of Listeria monocytogenes and indicates that your cleaning and sanitation practices may not be adequate.


© 2017 US Food Safety Corporation. No copyright claim is made for portions of this blog and linked items that are works of the United States Government, state governments or third parties.

Posted in: Family safety